Electric Motor Torque Rpm Curve

In practice a shunt motor cannot run at its peak power or torque as the currents involved are too large.

Electric motor torque rpm curve.

N revolution per minute rpm alternatively. One is a plot of empirical data and the other was plotted mechanically using a device developed at mit. The engine is designed to make peak power and peak torque at very high rpm above 8 000 versus zero. At full load torque the speed of the electric motor is slightly less than the synchronous speed as shown in the curve above.

Figure 1 provides a graphical illustration of these changes. That is why the shaft and frame of a 900 rpm motor are usually larger than those of an 1 800 rpm motor of the same hp. The linear model of a d c. Introduction of a vfd when the speed of an ac motor is controlled by a vfd hp or torque will change depending on the change in frequency.

T inlb torque in lb f. For example the ac motor found in the tesla roadster 2008 produces near constant maximum torque from 0 to about 6000 rpm while maximum power occurs at about 10000 rpm long after torque begins to drop off. The honda s2000 on the other hand has decent power 265 whp but low torque at just 163 lb ft. 1 ft lb f 1 356 nm.

The shunt motor also has a linear torque speed characteristic and similarly shaped power curve. In this overlay the shaded area reflects the accelerating torque available from the motor to drive the pump. T ftlb torque lb f ft. Motor torque speed curve is a very good approximation.

Full load torque is developed with the motor operating at rated voltage frequency and load. Torque in imperial units can be calculated as. By overlaying the torque speed curve of a pump and a motor one can verify that the motor is producing enough accelerating torque to drive the pump to full speed as shown below. The roadster s redline is 14000 rpm.

T ftlb p hp 5252 n 1b. T inlb p hp 63025 n 1. Electrical motor power velocity and torque equations. Other electric motors may in fact produce maximum torque throughout their entire operating range.

As a current flows through the electric motor a related electrical charge causes an armature to rotate. Like pumps motors produce a torque speed curve of their own. The torque speed curves shown below are actual curves for the green maxon motor pictured at right used by students in 2 007. Thankfully in electric motors maximum torque is produced from the get go.